P0414 — AIR System Switching Valve A Circuit Shorted

What Does P0414 Mean?

P0414 is a diagnostic trouble code indicating: AIR System Switching Valve A Circuit Shorted. This code relates to the emission controls system. It has been reported in NHTSA complaints across 2 different vehicle models.

The emission control system reduces harmful exhaust pollutants through several subsystems: EGR (Exhaust Gas Recirculation) recirculates a portion of exhaust back into the intake to lower combustion temperatures and reduce NOx. The secondary air injection system pumps fresh air into the exhaust during cold starts to help the catalytic converter light off faster. The catalytic converter converts CO, HC, and NOx into CO2, H2O, and N2. The EVAP system captures fuel vapors from the tank and purges them into the engine for combustion. When any of these systems malfunction, the vehicle will fail emissions testing and the ECM will set a DTC.

Symptoms of P0414

⚠️ Check engine light on
⚠️ Failed emissions/smog test
⚠️ Possible rough idle or stalling (EGR stuck open)
⚠️ Fuel smell (EVAP leak)
⚠️ Reduced performance in some cases
⚠️ Increased tailpipe emissions

Common Causes

🔍 Carbon buildup causing EGR valve to stick
🔍 EVAP system leak (gas cap, hose, canister, purge valve)
🔍 Catalytic converter below efficiency threshold (aging)
🔍 Secondary air pump failure or check valve stuck
🔍 Wiring or vacuum line issue in emission control circuit

P0414 Reports by Year

2011

1

2012

1

Real Owner Reports

From NHTSA complaint database — actual owner descriptions.

"CODE P1410 SECONDARY AIR INJECTION SYSTEM SWITCHING VALVE STUCK OPEN. THIS IS A COMMON ERROR MANY 2006 AND UP SUBARU IMPREZA WRX OWNERS ARE HAVING. THE EMISSIONS SYSTEM IS PRONE TO FAIL DUE TO CARBON BUILDUP OR MOISTURE AND RUST CONTAMINATING VALVES, LEADING TO REPAIRS COSTING $700 TO $1500. THIS FA"
— Subaru Impreza owner, 04/01/2011

"CODE P1410 SECONDARY AIR INJECTION SYSTEM SWITCHING VALVE STUCK OPEN. THIS IS A COMMON ERROR MANY 2006 AND UP SUBARU IMPREZA WRX OWNERS ARE HAVING. THE EMISSIONS SYSTEM IS PRONE TO FAIL DUE TO CARBON BUILDUP OR MOISTURE AND RUST CONTAMINATING VALVES, LEADING TO REPAIRS COSTING $700 TO $1500. TH"
— Subaru Wrx owner, 01/31/2012

Source: NHTSA Complaints Database

Most Reported Vehicles for P0414

Based on NHTSA owner complaint data.

#	Vehicle	Reports
1	SUBARU IMPREZA
2	SUBARU WRX

Diagnostic Tips

For EVAP codes: start with the gas cap — tighten it and clear the code. If it returns, use a smoke machine to find the leak
For EGR codes: remove and inspect the EGR valve — carbon buildup causing sticking is extremely common and cleanable
For catalyst codes: check upstream O2 sensor first — a bad sensor can falsely report low catalyst efficiency
For secondary air codes: listen for the air pump running during cold start — it should run for 30-90 seconds

Common Mistakes to Avoid

❌ Replacing the catalytic converter based on a P0420/P0430 code alone — diagnose the root cause first (O2 sensor, exhaust leak, engine running rich)
❌ Ignoring a loose gas cap as the cause of EVAP codes — this is literally the #1 cause and the cheapest fix
❌ Using aftermarket catalytic converters in states with strict emissions laws (California) — CARB-compliant converters are required

Frequently Asked Questions

Will I pass emissions with a check engine light on?

No. In all US states that require emissions testing, a lit check engine light is an automatic failure regardless of actual tailpipe emissions. The code must be cleared AND the readiness monitors must complete before testing.

Can I just clear the code before emissions testing?

No. After clearing codes, the ECM's readiness monitors reset and must complete a full drive cycle before the vehicle can pass inspection. Most testing facilities check monitor status — incomplete monitors = automatic failure.

How much does a catalytic converter cost?

OEM: $500-$2500+ depending on vehicle. Aftermarket: $200-$800 but must be CARB-compliant in California and several other states. Labor: $100-$500. Some vehicles have 2-4 converters, so total costs can be significant.

Reported Repair Costs for P0414

Based on 8 owner-reported repair costs from NHTSA complaints.

Low End

$150

Typical

$700

High End

$1500

⚠️ These are owner-reported costs, not estimates. Actual costs vary by location, labor rates, and root cause. Source: NHTSA complaints database.

What To Do Next

Possible Fixes

🔧 Clean or replace EGR valve
🔧 Replace gas cap (EVAP codes)
🔧 Replace EVAP purge or vent solenoid
🔧 Replace catalytic converter
🔧 Replace secondary air pump or check valve

1
Find your vehicle above
Click your make and model for real owner reports and common causes specific to your vehicle.
2
Check for recalls
Go to nhtsa.gov/recalls and enter your VIN. Free repairs if covered.
3
Get a professional diagnosis
A code alone doesn't identify the exact failed part. A diagnostic ($50–$150) pinpoints the root cause.

P0414: AIR System Switching Valve A Circuit Shorted